Note: Individual characteristics are also given in the text of the Chapter and, if their implementation is mandatory, are highlighted in bold.
| Ignition/gasoline engine control system Type electronic ME SFI 2.0 or HMS. 2 spark plugs per cylinder, individually controlled and working in series, with their own ignition coils, combined in one housing. | Ignition advance angle, degrees before TDC | Determined by the control unit in the range | 0 – 14.5 | The shift between the start and end of a series of sparks of paired candles | 0 – 10 degrees. Spark plugs | Type | Interelectrode gap, mm |
| 0.99 |
| 0.99 Firing order |
| 1-4-3-6-2-5 |
| 1-5-4-2-6-3-7-8 Diesel Engine Management System | | Type Electronic with direct injection "Common-Rail", turbocharging and aftercooling | | Malfunction Indicator Lamp (MIL) Flashes when there are misfires, lights up constantly when there are other malfunctions in the control system | Tightening forces of threaded connections, H•m | | Spark plugs | 20 - 30 | ||||||||||
OBD II 2nd Generation On-Board Diagnostic Codes
Power unit | | P0000 | No fault codes in the system memory. | P0100 | Malfunction in the intake air mass sensor (MAF) circuit. Right bank of cylinders. | P0105 | Malfunctions in the intake air mass (MAF) sensor circuit. Right bank of cylinders. | P0110 | Malfunction in the intake air temperature (IAT) sensor circuit. Right bank of cylinders. | P0115 | No or excessively low signal level from the coolant temperature sensor (ECT). Right bank of cylinders. | P0120 | Throttle Position Sensor (TPS) Circuit Malfunctions. Right Bank of Cylinder. | P0130 | Malfunction in the pre-catalytic lambda probe circuit (right bank of cylinders). Right row of cylinders. | P0133 | Pre-catalytic heated lambda probe voltage too high or response too slow (right bank of cylinders). | P0135 | Malfunction in the pre-catalytic lambda probe heating circuit (excessively high voltage) (right bank of cylinders). | P0136 | Malfunction in the post-catalytic heated lambda probe circuit (excessively low voltage) (right bank of cylinders). | P0140 | Malfunction in the pre-catalytic lambda probe heating circuit (right bank of cylinders) G3/4. | P0141 | Malfunction in the heating circuit of the post-catalytic lambda probe (right bank of cylinders) G3/6. | P0150 | Malfunction in the pre-catalytic lambda probe circuit (left bank of cylinders). | P0153 | Slow response of pre-catalytic lambda probe (left bank of cylinders). | P0155 | Malfunction of the pre-catalytic lambda probe heater (left bank of cylinders) G3/3. | P0156 | Post-catalytic lambda probe is faulty (left bank of cylinders) G3/5. | P0160 | Malfunction of the pre-catalytic lambda probe heater (left bank of cylinders) G3/3. | P0161 | Malfunction of the post-catalytic lambda probe heater (left bank of cylinders) G3/5. | P0170 | Too lean or too rich of the air-fuel mixture (right bank of cylinders). | P0173 | Lean or rich injection (left bank of cylinders). | P0201- P0212 | Malfunction in the injector circuit of cylinders 1 - 12 respectively. | P0300 | There are random misfires in various cylinders. | P0301 - P0312 | There are misfires in cylinders 1–12, respectively. | P0325 | Knock sensor 1 is faulty (right bank of cylinders). | P0330 | Knock sensor 2 is faulty (right bank of cylinders). | P0335 | Malfunction in the circuit of the crankshaft position sensor SKR. Right row of cylinders. | P0341 | Malfunction of the CMP sensor. Right row of cylinders. | P0370 | Displacement of the camshaft phase relative to the crankshaft. | P0400 | Exhaust gas recirculation flow malfunction. | P0410 | Malfunction in the additional air mixing system. | P0422 | The efficiency of the catalytic converter has been excessively reduced (right bank of cylinders). | P0432 | The efficiency of the catalytic converter has been excessively reduced (left bank of cylinders). | P0440 | EVAP Evaporative Emission System Leaks | P0441 | EVAP VSV valve is faulty | P0442 | Minor leak detected in EVAP system | P0443 - P0446 | EVAP Canister Purge Control Valve Circuit Malfunction | P0450 | EVAP Fuel Tank Vapor Pressure Sensor Circuit Malfunction | P0455 | Major leak detected in EVAP system | P0460 | Low fuel level in tank. | P0462 | Short circuit to ground in the fuel level sensor circuit. | P0500, P0501 | Vehicle speed sensor VSS circuit malfunction. | P0507 | Unexpected increase in engine speed when the idle speed stabilization system is activated. | P0560 | Malfunction in the on-board electrical system. | P0565 | Violation in generating the signal to turn on the cruise control. | P0600 | AT control unit serial port malfunction. | P0604 | RAM error in the control module. | P0605 | ROM error in the control module. | P0700 | Malfunction of the transmission control system. | P0702 | Electrical fault in transmission control system circuit. | P0715 | Malfunction in the input circuit of the turbine speed sensor circuit. | P0720 | Malfunction in the speed sensor circuit. | P0730 | Incorrect selection of AT gear. | P0740 | Malfunction in the circuit of the solenoid valve of the TSS AT rotation converter. | P0743 | Electrical failure in the torque converter clutch circuit. | P0748 | Electrical fault in pressure control solenoid valve circuit. | P0753 | Electrical fault in shift solenoid valve A circuit. | P0758 | Electrical fault in shift solenoid valve B circuit. | P0763 | Electrical fault in shift solenoid valve C circuit. | P0801 | Engine/KV electric fan motor malfunction (M4/3). | P0802 | Malfunction of the resonance intake manifold switching valve (Y22/6). | P0809 | Displacement of the camshaft phase relative to the crankshaft. | P0811 | Blocked distributed CAN bus from electronic ignition | P1031 | The lambda probes are connected incorrectly (G3/3 and G3/4). | P1177 | Oil sensor failure B40 (level, temperature, quality), oil temperature deviation. | P1178 | Oil sensor failure B40 (level, temperature, quality), oil level deviation. | P1179 | Oil sensor failure B40 (level, temperature, quality), deviation in oil quality. | P1180 | Oil sensor failure B40 (level, temperature, quality), excess oil temperature. | P1181 | Engine/CB electric fan motor malfunction. | P1185 | Oil sensor failure B40 (level, temperature, quality), water in oil. | P1186 | Fuel cut-off emergency signal. Activator M16/6 of electronic gas pedal/crankcase/idle speed stabilization. | P1225 | Malfunction of the resonance intake manifold switching valve (Y22/6). | P1233 | Activator M16/6 electronic gas pedal/cruise control/idle speed control. | P1355 | Right bank cylinder shut-off valve (Y80). | P1356 | Left bank cylinder shut-off valve (Y81). | P1357 | The cylinders are deactivated, the intake valves of cylinders 2, 3, 5 or 8 continue to operate. | P1358 | The cylinders are not switched off, the exhaust valve of cylinder 5 does not work. | P1359 | The cylinders are not switched off, the exhaust valve of cylinder 2 does not work. | P1360 | The cylinders are not switched off, the exhaust valve of cylinder 3 does not work. | P1361 | The cylinders are not switched off, the exhaust valve of cylinder 8 does not work. | P1366 | Exhaust system switching valve. | P1380 | The inlet valve of one of the cylinders does not work, although the cylinders have not been switched off. | P1386 | Knock control from ECM. | P1400 | The vacuum transmitter (Y31/1) of the EGR valve is faulty. | P1420 | Switch valve (Y32) of the secondary air mixing system AIR pump. | P1453 | Relay module (K40) for secondary air mixing system AIR, air pump (K40/4k3). | P1491 | Too high refrigerant pressure KV. | P1542 | Accelerator pedal sensor (B37). | P1570 | Blocking launch attempt (rCL Remote Control Models); CAN signal compatibility failure from DAS driver recognition control module to ECM or EECM and DAS | P1580 | Activator (M16/1) of electronic gas pedal/cruise starter/idle speed control drive EA/CC/ISC. | P1584 | Brake light switch (S9/1). | P1603 | Distributed CAN data bus from EIS | P1605 | Bad driving conditions are determined by comparing driving speed signals | P1642 | Engine control unit ECM (N3/10) incorrect coding. | P1644 | Due to low voltage of the transmission control unit (N15/3), it is not possible to determine the transmission version. | P1666 | The cylinder shut-off valve does not open, although the cylinders have been shut off. | P1681 | Lost collision signal. | P1747 | Distributed bus (CAN) signal error from the ETC transmission control unit (N15 / 3) or dashboard. Chassis (aBS/ASR/ETS/ESP systems) | | C1000 | ESP/SPS control unit (N47-5). | C1010 | Low supply voltage, circuit 87 | C1011 | Open/short circuit in the power supply circuit of the solenoid valve of the ASR/ETS/ESP hydraulic unit | C1020 | Distributed CAN data bus communication fault. Check control unit coding | C1022 | Distributed data bus communication failure with engine control unit (ME-SFI, N30/10) or right engine control unit (ME-SFI, N3/12). | C1023 | Distributed data bus communication fault with left engine control unit (ME-SFI, N3/11). | C1024 | Distributed data bus communication fault with transmission control unit (N15/3). | C1100 | Break, poor contact, damage to the rotor teeth of the vehicle speed sensor on the left front wheel (L6/1), different wheel size, incorrect final drive ratio. | C1101 | Break, poor contact, damage to the rotor teeth of the vehicle speed sensor on the right front wheel (L6/2), different wheel size, incorrect final drive ratio. | C1102 | Broken, poor contact, damaged teeth of the rotor of the vehicle speed sensor on the left rear wheel (L6/3), different wheel size, incorrect gear ratio of the final drive. | C1103 | Broken, poor contact, damaged teeth of the rotor of the vehicle speed sensor on the left rear wheel (L6/4), different wheel size, incorrect gear ratio of the final drive. | C1120 | Open circuit, short circuit in the reference or working signal wire of the ESP stability control sensor (N64). | C1140 | Open circuit, short circuit, initialization of the steering angle sensor (N49). | C1141 | ESP brake pressure sensor (B34). | C1142 | Open circuit, short circuit in the ABS lateral acceleration sensor circuit (B24/2). | C1200 | Open circuit, short circuit, malfunction of the 4-pin brake light switch sensor (S9/1). | C1300 | Open circuit, short circuit in the circuit of the holding solenoid valve of the left front wheel (A7/3y6). | C1301 | Open circuit, short circuit of the left front wheel release solenoid valve circuit (A7/3y7). | C1302 | Open circuit, short circuit in the circuit of the retaining solenoid valve of the right front wheel (A7/3y8). | C1303 | Open circuit, short circuit of the release solenoid valve of the right front wheel (A7/3y9). | C1304 | Open circuit, short circuit of the circuit of the holding solenoid valve of the left rear wheel (A7/3y10). | C1305 | Open circuit, short circuit in the circuit of the release solenoid valve of the left rear wheel (A7/3y11). | C1306 | Open circuit, short circuit in the circuit of the retaining solenoid valve of the right rear wheel (A7/3y12). | C1307 | Open circuit, short circuit in the circuit of the release solenoid valve of the right rear wheel (A7/3y13). | C1308 | Open circuit, short circuit in the front wheel solenoid valve circuit. | C1309 | Open circuit, short circuit in the rear wheel solenoid valve circuit. | C1310 | Open circuit, short circuit in the front wheel shift valve circuit. | C1311 | Open circuit, short circuit of the rear wheel shift valve circuit. | C1312 | Master brake cylinder switching valve. | C1313 | Hydraulic unit solenoid valve relay. Replace the control unit. | C1400 | Open circuit, short circuit in the ASR/ESP pump circuit. | C1401 | Open, short or failure to turn off the high pressure pump/valve body return circuit. | C1500 | Vehicle speed sensor VSS. | C1501 | SPS pressure sensor. | C1503 | Piston pressure transfer unit. Check condition of rear brake pads | C1504 | The system is disabled. The steering angle sensor (N49) is not initialized, low power supply of the ESP stability sensor. | ||
Body (automatic air conditioning system)
| Display | OBD II Tester |
|
| 26 | B1026 | Transmission to CAN data bus. |
| 226 | B1226 | Interior temperature sensor. |
| 227 | B1227 | Outside temperature indicator sensor. |
| 228 | B1228 | Left heater temperature sensor. |
| 229 | B1229 | Right heater temperature sensor. |
| 230 | B1230 | Evaporator temperature sensor. |
| 231 | B1231 | Coolant Temperature Sensor (DFI, IFI) |
| 232 | B1232 | Refrigerant pressure sensor. |
| 233 | B1233 | Coolant temperature sensor. |
| 234 | B1234 | Solar radiation sensor. |
| 235 | B1235 | Emission sensor. |
| 241 | B1241 | Add refrigerant. |
| 416 | B1416 | Coolant circulation pump. |
| 417 | B1417 | Water valve left. |
| 418 | B1418 | Water valve right. |
| 419 | B1419 | Electromagnetic clutch. |
| 420 | B1420 | Increase in idle speed. |
| 421 | B1421 | Pulse module. |
| 422 | B1422 | Serial interface to the instrument cluster. |
| 423 | B1423 | Switching valve block. |
| 424 | B1424 | The adsorber drive is open. |
| 425 | B1425 | The adsorber drive is closed. |
| 432 | B1432 | Maximum heating. |
| 459 | B1459 | Serial interface to the instrument cluster. |
| 460 | B1460 | LED – central air deflector, "Heating" position. |
| 461 | B1461 | LED – central air deflector, "Cooling" position. |
| 462 | B1462 | Fully open position of the WOT throttle (diesel models). |
Security systems
| Without side airbags (control unit code starts with 000) 1 Security system control unit. | 2 | Open or short circuit in the driver's airbag ignition circuit. | 3 | Open or short circuit in the driver's belt tensioner ignition circuit. | 4 | Open or short circuit in the front passenger seat belt tensioner ignition circuit. | 5 | Open or short circuit in the front passenger airbag ignition circuit. | 10 | The control unit programming does not match the vehicle version. | 17 | Low supply voltage (15R circuit). | 19 | Open or short circuit to positive in the safety system warning lamp circuit. | 20 | Front passenger seat occupancy sensor - airbag activation. | 24 | Driver seat belt fastening sensor (uS models). | 25 | Front passenger seat belt fastener sensor (uS models). | 73 | Open or short circuit of the ignition circuits. With side airbags (control unit code starts with 001) 1 Security system control unit. 2 Open or short circuit to positive in the safety system warning lamp circuit. 3 Low supply voltage. 4 Open or short circuit in driver's airbag ignition circuit, control unit programming. 5 Open or short circuit in the driver's belt tensioner ignition circuit, control unit programming. 6 Open or short circuit in the front passenger seat belt tensioner ignition circuit, control unit programming. 7 Open or short circuit in the front passenger airbag ignition circuit, control unit programming. 8 Open or short circuit in the driver's side airbag ignition circuit, programming of the control unit. 9 Open or short circuit in the front passenger side airbag ignition circuit, control unit programming. 16 Driver seat belt fastening sensor (uS models). Programming the control unit. 17 Front passenger seat belt fastener sensor (uS models). Programming the control unit. 18 Left side airbag wiring fault. 19 Open, short, or low voltage in the left side airbag crash sensor circuit. 20 Open, short, or low voltage in the left side airbag crash sensor circuit. 21 Right side airbag wiring fault. 22 Open, short, or low voltage in the right side airbag crash sensor circuit. 23 Open, short, or low voltage in the right side airbag crash sensor circuit. 24 Seat occupancy sensor - activation of front airbags. 25 Front passenger seat occupancy sensor - activation of the front airbag. 26 Programming the control unit. 27 Open or short circuit in the front passenger seat occupied sensor with child restraint system (ACSR) circuit. 28 Front passenger seat occupied sensor with child seat installation sensor (ACSR). Child seat not installed correctly or child seat not connected to passenger seat. Metal objects on passenger or child seat. Nearby electromagnetic emitter (telephone, transmitter, etc.). 29 Programming the control unit. 31 Front passenger seat occupancy sensor with child seat position sensor (ACSR). 32 Damage in the left side airbag crash sensor circuit (A53). 33 Damage in the right side airbag crash sensor circuit. 34 Digital Crash Output - Wiring Fault (ARTHUR). Control Unit Programming. 35 Analog Crash Output - Wiring Damage. B1558 Child seat installation indicator light. B1559 Child restraint system (ACSR) information signal. | |||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||