Car manual transmission Mercedes 190 (W201)
Technical data
General Provisions Gearbox code: 4 - speed gearbox - 716.2 5 - speed gearbox - 717.4 Gearbox oil Type - Oil recommended by Mercedes-Benz for manual transmissions...
General Provisions Gearbox code: 4 - speed gearbox - 716.2 5 - speed gearbox - 717.4 Gearbox oil Type - Oil recommended by Mercedes-Benz for manual transmissions...
General information
4- and 5-speed gearboxes are available. The gearbox is housed in a housing bolted to the rear of the engine. The rotation from the crankshaft is transmitted through the...
4- and 5-speed gearboxes are available. The gearbox is housed in a housing bolted to the rear of the engine. The rotation from the crankshaft is transmitted through the...
Manual Transmission Oil — Draining and Filling
Note: To remove the drain and filler plugs you will need a hex key or a suitable replacement (see text). 1. Place a suitable container under the transmission drain plug...
Note: To remove the drain and filler plugs you will need a hex key or a suitable replacement (see text). 1. Place a suitable container under the transmission drain plug...
Gearshift Mechanism Parts — Removal, Installation and Adjustment
Gear shift lever Removal 1. Pull the gearshift boot off the center console and twist it up over the gearshift lever. 2. Using a screwdriver, pry the spring ring out of...
Gear shift lever Removal 1. Pull the gearshift boot off the center console and twist it up over the gearshift lever. 2. Using a screwdriver, pry the spring ring out of...
Oil seals — replacement
Primary shaft oil seal 1. Remove the gearbox as described in paragraph 6 . 2. Remove the clutch release bearing as described in Chapter 6 . 3. Loosen the mounting bolts...
Primary shaft oil seal 1. Remove the gearbox as described in paragraph 6 . 2. Remove the clutch release bearing as described in Chapter 6 . 3. Loosen the mounting bolts...
Reverse Light Switches — Checking, Removing and Installing
Examination 1. The reverse light circuit is controlled by a plunger type switch located at the rear of the gear selector lever under the center console. If you find a...
Examination 1. The reverse light circuit is controlled by a plunger type switch located at the rear of the gear selector lever under the center console. If you find a...
Manual gearbox — removal and installation
Removal Note: Due to poor access to the transmission-to-engine mounting bolts, this operation is quite difficult. It is recommended to read the description carefully...
Removal Note: Due to poor access to the transmission-to-engine mounting bolts, this operation is quite difficult. It is recommended to read the description carefully...
Gearbox Repair — Basics
Manual transmission repair is a difficult job for a DIYer. The repair requires removing and installing many small parts. Numerous gaps must be accurately measured and,...
Manual transmission repair is a difficult job for a DIYer. The repair requires removing and installing many small parts. Numerous gaps must be accurately measured and,...
This section is available on: russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian
More similar sections for repairing other models
☛ Transmission: Transmission car Mercedes W168 (1997-2004)
☛ Transmission: Mechanical gearbox car Mercedes W210 (1996-2002)
☛ Transmission: Mechanical gearbox car Mercedes W163 (1997-2005)
☛ Transmission: Mechanical gearbox 717.454 car Mercedes W140 (1991-1998)
☛ Transmission: Mechanical gearbox car Mercedes Sprinter (1995-2000, diesel)
Link in different formats to this section
TEXTHTMLBB Code
- General information
- Introduction to guide
- User manual
- Maintenance
- Power unit
- Gasoline engines
- Diesel engines
- Cooling system
- Ventilation and heating
- Supply system
- Injection system (gasoline)
- Injection system (diesel)
- Exhaust system
- Ignition and control system
- Charge and launch systems
- Transmission
- Mechanical gearbox
- Automatic gearbox
- Clutch and drive shafts
- Differential
- Chassis
- Brake system
- Car suspension
- Steering
- Body
- Exterior (external elements)
- Interior (internal elements)
- Electrical equipment
- Equipment and devices
- Lighting system
- Electrical diagrams (2000)
- Electrical diagrams (since 2001)
- General information
- User manual
- Driving a car
- Car care
- Maintenance
- Power unit
- Gasoline engines
- Diesel engines
- Lubrication system
- Cooling system
- Heating and ventilation
- Ignition system
- Fuel system
- Injection system (gasoline)
- Injection system (diesel)
- Exhaust system
- Transmission
- Clutch
- Car gearbox
- Chassis
- Suspension, wheels and tires
- Steering
- Brake system
- Body
- Exterior (external elements)
- Interior (internal elements)
- Doors and windows
- Electrical equipment
- Equipment and devices
- Power devices
- Lighting system
- Electrical circuits
- General information
- Introduction to the guide
- Operation and care
- Maintenance (gasoline)
- Maintenance (diesel)
- Troubleshooting
- Power unit
- Petrol engine I4
- Petrol engine V6
- Diesel engines
- Engine overhaul
- Cooling and heating
- Power system (carburetor)
- Injection system (gasoline)
- Injection system (diesel)
- Exhaust system
- Charge and start system
- Ignition system (I4)
- Ignition system (V6)
- Diesel heating system
- Transmission
- Clutch
- Mechanical gearbox
- Automatic gearbox
- Cardan shaft and axle shafts
- Chassis
- Brake system
- Car suspension
- Steering
- Body
- Exterior (external elements)
- Interior (internal elements)
- Doors, locks and windows
- Electrical equipment
- Equipment and devices
- Electrical circuits