Charging and starting system Mercedes M-Class (W163)

Charging and starting systems — general information
The battery on all M-Class models is located in the right rear corner of the engine compartment 1 - Ground wire; 5 - aika; G1 - Battery; W16/4 - Body assembly ground...

Battery — General information, maintenance recommendations
The 12-volt battery installed in the car consists of six cans, in which positive and negative plates (lamellas) are placed, immersed in a solution of sulfuric acid. The...

Charging system — general information and safety precautions
All models under consideration use an alternator. When installing additional electrical equipment, check that the generator capacity is sufficient to provide new...

Checking the charging system
1. Remember that a faulty alternator is not the only possible cause of a malfunction in the charging system. If you detect signs of a system failure, perform the...

Removal and installation the generator
Generator installation details for gasoline models 1 - Terminal 30 (B+); 2 - Terminal 61 (D+); 3 - Bolts; G2 - Generator 1. The details of the generator installation on...

Removal and installation the generator drive pulley
Note: When replacing a generator with a mileage of more than 100,000 km, its drive pulley should also be replaced. Petrol models Generator Drive Pulley Installation...

Removal and installation the voltage regulator
Voltage Regulator Installation Details 1. The details of the voltage regulator installation are shown in the illustration. All references in the text refer to this...

Engine Starting System — General Information and Precautions
The sole purpose of the engine starting system is to ensure that the engine rotates at a speed sufficient to start it. The starting system consists of a starter,...

Removal and installation the starter
Starter installation details for models 163.136 and 163.113 (engines of series 111 and 612) 1 - Terminal 30; 2 - Terminal 50; 3 - Screws; M1 - Starter 1. The starter...

This section is available on: russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

More similar sections for repairing other models

☛ Power unit: Charge and start system car Mercedes 190 (W201) (1982-1993)
☛ Power unit: Starting and charging system car Mercedes W124 (1984-1995)
☛ Power unit: Charging and starting system car Mercedes W463 (1999-2019)
☛ Power unit: Charge and launch system car Mercedes W140 (1991-1998)

Share with friends:

Link in different formats to this section

TEXTHTMLBB Code

W163 (1997-2005)